Mazergroup.ca

Material Safety Data Sheet
Revision Number: 000.0
Issue date: 11/23/2010
1. PRODUCT AND COMPANY IDENTIFICATION
Product name:
Loctite Threadlocker Red 271
IDH number: 209741
Product type:
Company address:
Contact information:
MEDICAL EMERGENCY Phone: Poison Control Center 1-877-671-4608 (toll free) or 1-303-592-1711 TRANSPORT EMERGENCY Phone: CHEMTREC 1-800-424-9300 (toll free) or 1-703-527-3887 Internet: www.henkelna.com 2. HAZARDS IDENTIFICATION
EMERGENCY
OVERVIEW
Physical state:
FLAMMABILITY:
PHYSICAL HAZARD:
Personal Protection:
WARNING:
CAUSES EYE IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION. MAY CAUSE SKIN IRRITATION. MAY CAUSE RESPIRATORY TRACT IRRITATION. Relevant routes of exposure:
Potential Health Effects
Inhalation:
Skin contact:
May cause skin irritation. May cause allergic skin reaction. Eye contact:
Contact with eyes will cause irritation. Ingestion:
Not expected to be harmful by ingestion. Existing conditions aggravated by
exposure:
This material is considered hazardous by the OSHA Hazard Communication Standard (29 CFR 1910.1200). See Section 11 for additional toxicological information.
3. COMPOSITION / INFORMATION ON INGREDIENTS
Hazardous components
CAS NUMBER
4. FIRST AID MEASURES
Inhalation:
Move to fresh air. If symptoms develop and persist, get medical attention. Product name: Loctite Threadlocker Red 271 Skin contact:
Remove contaminated clothing and footwear. Wash with soap and water. Wash clothing before reuse. If symptoms develop and persist, get medical attention. Eye contact:
Flush with copious amounts of water, preferably, lukewarm water for at least 15 minutes, holding eyelids open all the time. Get medical attention. Ingestion:
Do not induce vomiting. Keep individual calm. Get medical attention. 5. FIRE FIGHTING MEASURES
Flash point:
> 93.3 °C (> 199.94 °F) Tagliabue closed cup Autoignition temperature:
Flammable/Explosive limits - lower:
Flammable/Explosive limits - upper:
Extinguishing media:
Special firefighting procedures:
Unusual fire or explosion hazards:
Hazardous combustion products:
Oxides of carbon. Oxides of sulfur. Oxides of nitrogen. Irritating organic vapours. 6. ACCIDENTAL RELEASE MEASURES
Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected
personnel.
Environmental precautions:
Do not allow product to enter sewer or waterways. Clean-up methods:
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder, sawdust). Store in a partly filled, closed container until disposal. 7. HANDLING AND STORAGE
Handling:
Prevent contact with eyes, skin and clothing. Do not breathe vapor and mist. Wash thoroughly after handling. Storage:
For safe storage, store at or below 38 °C (100.4 °F) Keep in a cool, well ventilated area away from heat, sparks and open flame. Keep container tightly closed until ready for use. For information on product shelf life, please review labels on container or check the Technical Data Sheet.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure
controls and protective equipment for each task performed.
Hazardous components
ACGIH TLV
AIHA WEEL
Product name: Loctite Threadlocker Red 271 Engineering controls:
No specific ventilation requirements noted, but forced ventilation may still be required if concentrations exceed occupational exposure limits. Respiratory protection:
If airborne concentrations are above the applicable exposure limits, use NIOSH approved respiratory protection. Use a NIOSH approved air-purifying respirator with an organic vapor cartridge. Eye/face protection:
Safety goggles or safety glasses with side shields. Skin protection:
Use impermeable gloves and protective clothing as necessary to prevent skin contact. Butyl rubber gloves. Natural rubber gloves. Neoprene gloves. 9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state:
Odor threshold:
Vapor pressure:
Boiling point/range:
Melting point/ range:
Specific gravity:
Vapor density:
Flash point:
> 93.3 °C (> 199.94 °F) Tagliabue closed cup Flammable/Explosive limits - lower:
Flammable/Explosive limits - upper:
Autoignition temperature: Not
Evaporation rate:
Solubility in water: Slight
Partition coefficient (n-octanol/water):
VOC content:
10. STABILITY AND REACTIVITY
Stability:
Hazardous reactions:
Hazardous decomposition products:
Phenolics. Oxides of sulfur. Oxides of carbon. Oxides of nitrogen. Irritating organic vapours. Incompatible materials:
Strong oxidizing agents. Strong acids. Copper Iron. Strong reducing agents. Rust. Conditions to avoid:
See "Handling and Storage" (Section 7) and "Incompatibility" (Section 10). 11. TOXICOLOGICAL INFORMATION
Acute oral product toxicity:
Acute dermal product toxicity:
OSHA Carcinogen
Hazardous components
NTP Carcinogen
IARC Carcinogen
(Specifically Regulated)
Product name: Loctite Threadlocker Red 271 Hazardous components
Health Effects/Target Organs
Allergen, Central nervous system, Corrosive, Irritant, Mutagen 12. ECOLOGICAL INFORMATION
Ecological information:
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal:
Follow all local, state, federal and provincial regulations for disposal. Hazardous waste number:
14. TRANSPORT INFORMATION
The shipping classifications in this sections are for non-bulk packaging only (unless otherwise specified). Shipping classification may be different for bulk packaging. U.S. Department of Transportation Ground (49 CFR)
Proper shipping name:
Hazard class or division:
Identification number:
Packing group:
International Air Transportation (ICAO/IATA)
Proper shipping name:
Hazard class or division:
Identification number:
Packing group:
Water Transportation (IMO/IMDG)
Proper shipping name:
Hazard class or division:
Identification number:
Packing group:
15. REGULATORY INFORMATION

United States Regulatory Information

TSCA 8 (b) Inventory Status:
All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. TSCA 12(b) Export Notification:
CERCLA/SARA Section 302 EHS:
CERCLA/SARA Section 311/312:
CERCLA/SARA 313:
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372). Cumene hydroperoxide (CAS# 80-15-9). This product contains the following toxic chemicals subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372). Saccharin (CAS# 81-07-2). Cumene hydroperoxide (CAS# 80-15-9). CERCLA Reportable quantity:
Saccharin (CAS# 81-07-2) 100 lbs. (45.4 kg) Cumene hydroperoxide (CAS# 80-15-9) 10 lbs. (4.54 kg) California Proposition 65:
This product contains a chemical known in the State of California to cause cancer. Product name: Loctite Threadlocker Red 271
Canada Regulatory Information
CEPA DSL/NDSL Status:
All components are listed on or are exempt from listing on the Canadian Domestic Substances List. WHMIS hazard class:
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: 8
Prepared by: Karim Nasr, Regulatory Affairs Specialist
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However,
Henkel Corporation does not assume responsibility for any results obtained by persons over whose methods Henkel
Corporation has no control. It is the user's responsibility to determine the suitability of Henkel's products or any
production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the
protection of property and persons against any hazards that may be involved in the handling and use of any of Henkel
Corporation's products. In light of the foregoing, Henkel Corporation specifically disclaims all warranties, express or
implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel
Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of any
kind, including lost profits.
Product name: Loctite Threadlocker Red 271

Source: http://www.mazergroup.ca/wp-content/uploads/2012/05/ZPX27136-Threadlocker-red.pdf